Pengaruh Konsentrasi Larutan Me2SnCl2 Terhadap Nilai Viskositas Larutan Konduktif Dalam Pembuatan Kaca Konduktif FTO

Tri Arini, Januar Irawan, Aga Ridhova, Lia Andriyah, Latifa Hanum Lalasari, F. Firdiyono

Abstract


Percobaan pendahuluan tentang pembuatan kaca konduktif fluorine-doped tin oxide (FTO) dilakukan dengan menggunakan metode spin coating. Penelitian ini menggunakan bahan baku dimethyltin dichloride (Me2SnCl2) sebagai prekursor dan ammonium florida (NH4F) sebagai doping. Hasil percobaan memperlihatkan bahwa nilai viskositas larutan SnO2:F yang dibuat dalam pelarut ethanol lebih besar daripada dalam methanol seiring meningkatnya konsentrasi Me2SnCl2. Pembuatan kaca konduktif fluorine-doped tin oxide (FTO) dengan metode spin coating, konsentrasi larutan optimum dalam penelitian ini berada pada konsentrasi 0,3M dengan pelarut ethanol dengan nilai resistansi 3,2 MΩ dimana pada konsentrasi tersebut semakin meningkat waktu spin coating maka resistansi akan semakin kecil.

Full Text:

PDF

References


Amma, D. Sumangala Devi, V. K. Vaidyan, and P. K. Manoj. 2005. “Structural,

Electrical and Optical Studies on Chemically Deposited Tin Oxide Films from Inorganic Precursors.” Materials Chemistry and Physics 93(1): 194–201.

Fikri, Dahlin., Yuwono Akhmad., Sofyan,Nofrijon., Arini,Tri., Hanum,Latifa.. 2017. “The Effect of Substrate Heating Temperature upon Spray Pyrolysis Process on the Morphological and Functional Properties of Fluorine Tin Oxide Conducting Glass.” In AIP Conference Proceedings, AIP Publishing, 02003 (1-9).

Greenfield, P F. 1976. “Viscosity Increases in Concentrated Sugar Solutions and Molasses Due To Dextrans.” (1972).

Karthick, P. Divya, Vijayanarayanan., S. Suja., M. Sridharan., 3 K. Jeyadheepan. 2015. “Opto-Electronic Properties of Fluorine Doped Tin Oxide Films Deposited by Nebulized Spray Pyrolysis Method.” Asian Journal of Applied Sciences 8(4): 259–68. http://www.scialert.net/abstract/?doi=ajap

s.2015.259.268 (October 14, 2016).

Lalasari, Latifa Hanum, Tri Arini, Akhmad Herman Yuwono, and F Firdiyono. 2015. “Pengaruh Pencampuran Dan Rasio Dopan/Prekursor Dalam Pembuatan Lapisa Tipis Flourine Doped Tin Oxide (FTO) Berbasis Timah (II) Klorida.” Majalah Metalurgi 3: 105–14.

Maddu, Akhiruddin, Rodo Tua Hasiholan, and Kurniati Mersi. 2009. “Penumbuhan Film Nanokristal SnO2 Dengan Metode Chemical Bath Deposition ( CBD ).” Nanosains & Teknologi l: 96–99.

Moholkar, A V, S M Pawar, K Y Rajpure, and C H Bhosale. 2008. “Effect of

Concentration of SnCl4 on Sprayed Fluorine Doped Tin Oxide Thin Films.”

Journal of Alloys and Compounds 455: 440–46.

Motin, M. A., M. H. Kabir, and M. E. Huque. 2005. “Viscosities and Excess Viscosities of Methanol, Ethanol and N-Propanol in Pure Water and in Water + Surf Excel Solutions at Different Temperatures.” Physics and Chemistry of Liquids 43(2): 123–37.

Muruganantham, G, K Ravichandran, and K Saravanakumar. 2011. “Effect of Solvent Volume on the Physical Properties of Undoped and Fluorine Doped Tin Oxide Films Deposited Using a Low-Cost Spray Technique.” Superlattices and Microstructures 50(6): 722–33.

http://dx.doi.org/10.1016 /j.spmi.2011.09.014.

Niemeyer, Wayne D. 2015. “SEM/EDS Analysis for Problem Solving in the Food Industry.” Scanning Microscopies 2015 9636: 96360G. Norrman, K., A. Ghanbari-Siahkali, and N. B. Larsen. 2005. “Studies of Spin-Coated Polymer Films.” Annual Reports on the Progress of Chemistry - Section C 101(May): 174–201.

Prisma, Antonius. 2012. “Pengaruh Konsentrasi Dan Viskositas Larutan

Polistiren Terhadap Morfologi Permukaan Dan Ketebalan Lapisan ZnPc Pada Permukaan QCM.” Natural B: 4–7.

Ramdhan, Zahid, and Aris Doyan. 2018. “Preliminary Study Flourine Tin Oxide (FTO ) Using Sol-Gel Spin Coating Techniques.” 10(2): 27–30.

Rinaldi, Rino, Amun Amri, and Khairat. 2016. “Sintesa Fluorinated Tin Oxide (FTO) Menggunakan Prekursor Ramah Lingkungan Dan Penambahan Graphene Dengan Metode Deposisi Spray Coating Untuk Aplikasi Material Konduktif Transparan.” Jom FTEKNIK 3(2): 10.

Syuhada, Dwi Bayuwati, and Sulaiman. 2008. “Pembuatan Konduktor Transparan Thin Film SnO2 Dengan Menggunakan Teknik Spray Pyrolisis.” Jurnal Fisika Himpunan Fisika Indonesia 8(1): 24–29.

Wang, Jian Tao, Xiang Lei Sh., Wei Wei Liu., Xin Hua Zhong., Jian Nong Wang., Leo Pyrah., Kevin D. Sanderson., Philip M. Ramsey., Masahiro Hirata., Keiko Tsuri. 2014. “Influence of Preferred Orientation on the Electrical Conductivity of Fluorine-Doped.” : 1–9.

Widiyandari, Hendri, Agus Purwanto, Eko Hidayanto, and Kuncoro Diharjo. 2012. “Fabrikasi Gelas Transparant Konduktif FTO (Flourine-Doped Tin Oxide) Dan Aplikasinya Pada Sel Surya Berbasis Dye (DSSC).” Prosiding InSINas: 88–92.


Refbacks

  • There are currently no refbacks.


==============================================================================================================

Prosiding SEMNASTEK Fakultas Teknik
Universitas Muhammadiyah Jakarta
Jl. Cempaka Putih Tengah 27
Jakarta Pusat 10510
T. 021.4256024, 4244016 / F. 021.4256023

ISSN : 2407 – 1846
e-ISSN : 2460 – 8416

==============================================================================================================

Powered by Puskom-UMJ